当前位置:首页 | 新闻中心

闪蒸干燥机——专题网站

闪蒸干燥机,旋转闪蒸干燥机,XZG旋转闪蒸干燥机

行业资讯

澳大利亚MICROTEC闪蒸干燥机

应用
  •马铃薯淀粉干燥
  •玉米淀粉干燥
  •A-淀粉干燥
  •B-淀粉干燥

概述
闪蒸干燥机是一种连续干燥装置,用于干燥湿饼各种崩解成细粉和湿滤饼用热空气干燥,以形成粉末。整个过程是完全自动的,无需处理或人为参与。进给速率的自动调整每在湿滤饼中的水分含量的变化,从而实现稳定的产品质量。
闪蒸干燥的原理是表面的水分瞬间蒸发。使用“闪蒸”,如干燥时间非常少,从毫秒到几秒钟。这是众所周知的事实,湿块状作为块状减小的大小增加的表面面积。湿滤饼解体成罚款,以增加表面积。
在进给机构送入湿滤饼。螺旋给料器给控制饲料在额定容量崩解剂。加热后的空气通过空气过滤器。热空气和湿滤饼得到彻底混合的崩解剂。发生在粉碎机的解体和干燥的湿饼。
湿滤饼迅速干燥,约50%的干燥中的崩解剂的地方。干燥管传达的粉碎材料气旋。输送管道干燥得到完成。
所用的时间解体粉干燥管道穿越被称为干燥的停留时间。该材料失去通过热空气被吸收的水分。的空气的温度降低,而它的湿度增加。粉中进一步干燥旋风。干粉末和空气分离发生在气旋。粉末的,从旋流器通过粉末排出阀排出。

经营效益和优势

强大的干燥和高效节能烘干机,干燥时间短,

连续干燥和简单的操作

搅拌得到的管道直径变化的气流的速度和干燥材料的变化,使干燥效率highLow停留时间 - ^小的暴露于热 - 保留了原有的产品质量。

专利设计的粉碎机,确保提供一致和均匀的粉末质量的湿饼和热空气的均匀混合。

可用容量
不同的能力是可用的。它不同从500公斤/小时。 10吨/小时。干淀粉

Application
• Potato starch drying
• Corn starch drying
• A-starch drying
• B-starch drying

General Description
Flash dryer is a continuous drying plant used for drying variety of wet cakes by disintegrating wet cake into fine powder and dried by hot air to form powder. The whole process is fully automatic requiring no handling or human involvement. The feed rate is adjusted automatically as per the variation in moisture content in wet cake thereby achieving consistent product quality.
The principle of Flash Drying is to evaporate surface moisture instantaneously. The word “flash” is used, as the drying time is very less from milli to few seconds. It is well known fact that the surface area of wet lump increases as the size of lump decreases. The wet cake is disintegrated into fines to increase the surface area.
Wet cake is fed in feed mechanism. The screw feeder gives controlled feed at rated capacity to disintegrator. The air after passing through Air Filter is heated . Hot air and wet cake get thoroughly mixed in the disintegrator. Disintegration and drying of wet cake takes place in disintegrator.
Wet cake is rapidly dried and about 50% drying take place in the disintegrator. Drying duct conveys the pulverized material to cyclone. Drying gets completed in conveying duct.
The time taken by disintegrated powder to travel through drying duct is called residence time of drying. The material looses moisture that is absorbed by hot air. The temperature of air reduces while its humidity increases. Powder is further dried in cyclone. Separation of dried powder and air takes place in cyclone. Powder is discharged from cyclone through powder discharge valves.

Operation Benefits and Advantages

Powerful drying and energy efficient dryer and short drying time

Continuous drying and simple operation

Variation of the duct diameter changes airflow’s speed and the drying materials gets stirred up,so the drying efficiency is highLow residence time – minimum exposure to heat – retains original product quality.

Proprietary design of disintegrator ensures uniform mixing of wet cake and hot air giving consistent and homogeneous powder quality.

Available Capacity
Different capacities are available. It varies from 500 kg/hr. to 10 tons/hr. dried starch